Studies on High-Voltage GaN-on-Si MIS-HEMTs Using LPCVD Si₃N₄as Gate Dielectric and Passivation Layer

Abstract

This paper investigates the performance of AlGaN/gallium nitride (GaN) MIS high electron mobility transistors (MIS-HEMTs). The gate dielectric layer and the surface passivation layer are formed by the low-pressure chemical vapor deposition (LPCVD) Si <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">3</sub> N <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">4</sub> . The LPCVD-Si <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">3</sub> N <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">4</sub> MIS-HEMTs exhibit a high breakdown voltage (BV) of 1162 V at I <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">DS</sub> = 1 μA/mm, a low OFF-state leakage of 7.7 × 10 <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">-12</sup> A/mm, and an excellent ON/OFF-current ratio of ~10 <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">11</sup> . Compared with the static ON-resistance of 2.88 mΩ · cm <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">2</sup> , the dynamic ON-resistance after high OFF-state drain bias stress at 600 V only increases to 4.89 mΩ · cm <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">2</sup> . The power device figure of merit = BV <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">2</sup> /R <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">ON.sp</sub> is calculated to be 469 MW · cm <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">-2</sup> . The LPCVD-Si <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">3</sub> N <sub xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">4</sub> /GaN interface state density is in the range of (1.4-5.3) × 10 <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">13</sup> eV <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">-1</sup> cm <sup xmlns:mml="http://www.w3.org/1998/Math/MathML" xmlns:xlink="http://www.w3.org/1999/xlink">-2</sup> extracted by the conventional conductance method. Finally, the gate insulator degradation of GaN-based MIS-HEMTs is analyzed by time-dependent dielectric breakdown test. The lifetime is extrapolated to 0.01% of failures after ten years at 300 K by fitting the data with a power law to a gate voltage of 10.1 V.