High pressure processing (HPP), as nonthermal processing technology, has the potential to increase the drying rate due to its improvement of heat and mass exchange in different processes. In this study, the moisture migration in shrimps during HPP-vacuum-freeze drying (HPP-VFD) processes has been monitored by using low-field nuclear magnetic resonance and magnetic resonance image (MRI) in comparison with hot air-drying and VFD. Based on the T₂ relaxation spectra, three water fractions corresponding to bound water (hydrogen-bonded water), immobile water (water trapped by organization structure or cell member), and free water were observed. For group B, with increasing drying time (4 to 22 hr), the transverse relaxation times of T₂₁ , T₂₂ , and T₂₃ were significantly decreased (76.79%, 57.78%, and 40.9%) (P < 0.05). The content of immobile water (A₂₂ ) and free water (A₂₃ ) decreased (81.55% and 89.07%), whereas the bound water (A₂₁ ) increased (7.26%). In comparison with group B, the T₂₁ , T₂₂ , and T₂₃ of group C showed greater decrease (83.12%, 87.12%, and 89.57% for group C) so that HPP pretreatment could shorten the relaxation time. MRI analysis further proved that HPP-VFD drying has improved drying efficiency, and moisture migration was from the exterior to the interior part with increasing drying time. SEM analysis demonstrated that no significant damage of muscle fibers with narrower gaps was observed for groups B and C. Overall, HPP, as a pretreatment technology, could accelerate the moisture migration and improve the drying efficiency of VFD process for shrimp. PRACTICAL APPLICATION: High pressure processing (HPP) is now well known as a nonthermal processing technology and becoming increasingly acknowledged. However, there is limited information about its application in shrimp-drying process and the moisture dynamic of shrimp subjected to high pressure processing-assisted vacuum-freeze drying. This study could provide valuable information regarding the moisture status and migration in HPP-VFD shrimp monitored by LF-NMR and MRI methods. The results showed that HPP processing at 550 MPa for 10 min can be used as an interesting method for drying pretreatment, increasing its drying rate and consequently reducing its process time, and it demonstrated that the methods used in this study had good correlation coefficient with physicochemical properties of shrimp, which may be real-time and nondestructive monitoring methods for shrimp-drying process.

#	Concept	H-Index	Publications	Citations
1	Engineering	15	30	695
2	Health Sciences	3	8	434
3	Medicine	3	6	121
4	Education	1	1	19
5	Management	1	1	10

	Year	Citations

About

Top Concepts